The RealTruck FlushFit TS is the cover we point truck owners to when they want retractable convenience without the manual latch-and-pull routine. It is the only electric retractable tonneau in the RealTruck family—open and close it from your truck’s key fob, an integrated cabin switch, or a button on the canister. No climbing into the bed, no wrestling a cover back into its housing, and no worries about whether it latched on the way home.
RealTruck engineered the FlushFit TS around twin synchronized motors that drive the cover evenly from both sides, so it tracks true and stays quiet even after years of use. The interlocking aluminum slats are knife-proof and built to hold 330 lbs. distributed on top, so you can stack cargo, throw a load of mulch in the bed, or mount a rack system on the integrated T-slot rails without worrying about the cover flexing. The fully flush, below-the-rails fit is the cleanest look in the retractable category—no bulky canister sitting above the bed line.
RealTruck tested the FlushFit TS from -40° to 180°F and zero to 95% humidity, so it is built to handle Phoenix summers and the occasional Alaska cold snap. A four-point water management system built into the side rails deflects rain out of the bed, and integrated LED bed lights fire up the moment the cover starts to open—handy when you are loading gear before sunrise or after a late shift. The tight-roll compact canister keeps cargo space loss to a minimum, and the automatic stop sensor lets you secure mixed loads by stopping the cover at any point without damaging the cargo underneath.
Installation runs about two hours and is largely a set-align-tighten job with minor wiring for the motors—RealTruck calls it a Level 3 (moderate) install with professional installation optional. We keep the FlushFit TS in stock at Camper Capital, and our Phoenix (downtown) and Peoria (west valley) install teams do these every week. Stop by either shop, see the cover on a display truck, and we will get you scheduled for a professional install the same week in most cases.
RealTruck assembles the FlushFit TS in Alabama and backs it with a 5-year limited warranty, with US-based product support behind it. If you are ready to step up to push-button retractable, call our Phoenix shop at 602.283.5935 or our Peoria shop at 602.962.6930 and we will walk you through bed length, T-slot rack compatibility, and the right motor harness for your truck.
